Entomopathogenic fungi as a promising biological control agent against banana fruit scarring beetle, Basilepta subcostata (Jac.) (Chrysomelidae: Coleoptera)

Abstract

Background

Banana fruit scarring beetle (BFSB), Basilepta subcostata (Jac.) (Chrysomelidae:Coleoptera), is an important insect pest feeds on leaf and fingers, which affects the cosmetic value of the fruit. The pest is distributed in Assam, Bihar, West Bengal, Chhattisgarh, and North-eastern Hill regions of India.

Results

The pest is currently managed by foliar spray with insecticides. In order to identify eco-friendly control of the pest, attempts were made to isolate microbial agent and evaluate their potential to control the pest. A total of 27 entomopathogenic fugal isolates were obtained from Odoiporus longicollis (Oliver), Cosmopolites sordidus (Germar), Basilepta subcostata (Jac), and other insect Galleria mellonella (Fabr). Based on colony morphology, the collected fungal isolates were identified as Metarhizium spp. (17) and Beauveria spp. (10). Through ITS sequencing, the fungal isolates were further characterized at species level as B. bassiana (8), B. brongniartii (2), M. anisopliae (8), M. robertsii (6), M. guizhouense (2), and M. pinghaense (1). Their sequences were submitted in GenBank and obtained accession numbers. Among 27 isolates tested against B. subcostata under laboratory conditions, 3 isolates (M. anisopliae NRCBEPF-36, M. pinghaense NRCBEPF-7 and B. brongniartii NRCBEPF-27) recorded 100% beetle mortality, followed by 11 isolates with 95–99% and 13 isolates with 88–93% within 8 days of treatment.

Conclusion

This study highlights the two native North East India isolates B. brongniartii NRCBEPF-27 (MT151781) and M. anisopliae NRCBEPF-36 (MT140308) showed the significance to use as potential biocontrol agents against banana fruit scarring beetle B. subcostata. Further experiments under field conditions are required to evaluate their biological control efficacy against the pest.

Background

Banana is the most important fruit crop and cultivated across 130 countries in the tropical and subtropical region. More than 200 species of insect and non-insect pests have been reported (Simmonds, 1966). The banana leaf and fruit scarring beetle Basilepta subcostata (Jacoby) (Chrysomelidae: Coleoptera) is considered as one of the most economically important pests in North-Eastern India (Mishra et al., 2015 and Bhagabati and Deka, 2016). Recently, taxonomic descriptions with illustrations of the genitalia of banana fruit and leaf scarring beetle led to correct identification of B. subcostata (Prathapan et al., 2019).

Entomopathogenic fungal (EPF) strains have been commercialized as a biocontrol agent, and the majority of them have been developed from Ascomycota, Beauveria spp. (Bals-Criv.) Vuill. (Hypocreales: Clavicipitaceae) and Metarhizium spp. (Metschn.) Sorok. (Hypocreales: Clavicipitaceae) (Rehner et al., 2011 and Velavan et al., 2017). The efficacy of Beauveria spp. has been well established as a potential biocontrol agent of Cosmopolites sordidus (Akello et al., 2008 and Lopes et al., 2013). EPF have been isolated and evaluated against banana stem weevil, Odoiporus longicollis and showed promising results (Padmanaban et al., 2019 and Alagesan et al., 2019). Additionally, the combined use of myco-insecticides and the full or reduced concentration of botanical/chemical insecticides is a promising pest-control option for minimizing adverse chemical effects (Samui et al., 2004 and Choudhary et al., 2010). In this study, an attempt was made to collect, isolate and identify promising EPF as a biocontrol agent for managing scarring beetle of banana.

Methods

Survey and collection of fungal infected insects

Survey was conducted to collect healthy and infected insects in Tamil Nadu, Bihar, and North-Eastern region (Assam) in India (Table1). Naturally infested banana stem weevils (Odoiporus longicollis Oliver), rhizome weevils (Cosmopolites sordidus Germar), several insect cadavers of leaf scarring beetle (Basilepta subcostata Jac), and other insect pests of the greater wax moth (Galleria mellonella L.) were collected (Table 1) and surface-sterilized with 1% sodium hypochlorite (NaOCl) for 30 s, followed by 3 washes with sterile distilled water to prevent external saprophytic contaminations. Dead insects were kept in Petri plate lined with a single layer of wet filter paper until signs of muscardine were observed. After that, they were dissected and placed into Petri plates containing potato dextrose agar yeast extract (PDAY) medium amended with antibiotic (1% yeast extract 0.6 g, 100 μg/ml chloramphenicol, 50 μg/ml streptomycin, 2 mg crystal violet), and the plates were incubated at 28±1 °C and 90% RH to facilitate growth and sporulation of the fungus. The cultures were purified using Veen’s medium containing Dodine (Veen and Ferron, 1966). Morphologically distinct colonies Beauveria and Metarhizium were picked individually and inoculated on PDAY medium and incubated at 27 °C for 15 days. After that, the fungal isolates were transferred to PDAY slants and used for further study. Also, slides were prepared (Riddell, 1950) from 5 days old culture for the identification and the cultures were stained with permanent stain (Cotton blue-Lacto phenol) and mounted using dinbutylphthalata in xylene (DPX). Identification was done on the basis of morphotaxonomic characters through microscopic inspection of conidia and conidiogenous structure (Bischoff et al., 2009 and Kepler et al., 2014). Also, for a long-term storage, spores were obtained from 5-day-old culture and mixed in 10% glycerol and stored at −30 °C until use.

Table 1 Entomopathogenic fungal isolates obtained from different banana pests and Galleria mellonella and their identity

Molecular characterization through sequencing of ITS region of entomopathogenic fungi (EPF) isolates

DNA was extracted from 50 to 100 g of lyophilized mycelium of the fungus from 10–15-day-old cultures grown in potato dextrose broth (PDB) following cetyltrimethylammonium bromide (CTAB) methods (Rogers and Bendich, 1994). Extracted DNA was suspended in EB buffer (10 mMTris–Hcl, pH 8.5) and stored at – 20 °C until used. The total DNA concentration was measured in spectrophotometer at 280 nm. PCR amplification of the non-coding region of internal transcribed spacer (ITS) of the nuclear ribosomal DNA was performed using a thermal cycler (Bio-Rad, T100^TM Thermal cycler). Each PCR reaction consisted of 25 μl reaction mixture containing 1X Taq buffer, 0.4–0.6 mM of each primer (ITS1 5′-CTCTCCAAACTCGGTCATTT-3′ and ITS2 5′-ATATGCTTAAGTTCAGCGGGT-3′), 0.2 mM of dNTP mix, 1U of Taq DNA polymerase (GeNei), and 20–50 ng/μl template DNA. The PCR amplification program had one initial cycle at 95 °C for 3 min, followed by 35 cycles of denaturation at 95 °C for 1 min, annealing 50 °C for 45 s extension at 72 °C for 2 min, a 2^nd final extension at 72 °C for 10 min. The PCR products were separated on 1% agarose gel containing 0.05% of EtBr in 0.5x TBE buffer (45 mM Tris acetate-1 mM EDTA, pH-8). A 100-bp DNA ladder (GeNei) was run on the same gel, and the size marker and bands were visualized under ultraviolet irradiation. The products (650 bp) from ITS region of 27 isolates were eluted from gel and sequenced using forwards and reverse primers, at sequences facility (Chromus Biotech, Bangalore, India). The sequences were analyzed in BLAST https://blast.ncbi.nlm.nih.gov, biosrv.cab.unina.it/webcap3. Based on similarity, the isolates were named and the sequences were submitted in NCBI-GenBank and obtained accession numbers.

Bioassay of EPF on Basilepta subcostata

The banana fruit scarring beetles (B. subcostata) were collected from the infested banana field and reared in entomology laboratory of the institute using perforated plastic containers at room temperature. The leaf midribs of cv. Jahaji (a susceptible host) were utilized for feeding the beetles. The entire test beetles were kept in these containers for at least 1 month before use in the experiments for acclimatization. Whereby beetles were observed using a hand lens and males were differentiated from females on the basis of punctuations on their rostrums spreading beyond the point of antennae insertion. These adult beetles were utilized for the present study.

The 27 indigenous EPF isolates were used for bioassay against B. subcostata. The cultures were grown on PDAY medium for 10 to 15 days at 25 ± 0.5 °C. The mycelia mat containing spores were harvested in tube using sterile distilled water 100 ml with continuous stirring the contents in a tube, filtered through a single layer of muslin cloth to remove debris and mycelia. Conidial suspension (CS) was prepared as per the procedure described by Lopes et al. (2013) and Velavan et al. (2017). The conidial concentration was estimated using hemocytometer under light microscope. Subsequently, the conidial suspension was diluted to make a final suspension of 1×10⁵ spores/ml with 0.1% Triton X-100, 0.2% Tween 80 and 0.1% glycerol. B. subcostata was transferred aseptically to fresh plastic boxes (10-cm diameter and 30-cm height). The conidial suspension of EPF isolates (27) were swabbed on leaf sheaths (8–10-cm lengths) individually. For comparison, 2 commercial isolates; each M. anisopliae and B. bassiana was also included in the experiment. Each treatment had 5 replications, and each replication consisted of 15 beetles. In control, similar numbers of beetles were introduced on to the leaf sheaths treated with water, 0.1% Triton X-100, 0.2% Tween 80, and 0.1% glycerol alone. Observations were taken on morality of insects at 3, 5, and 8 days after inoculations. Infected insect cadavers were transferred to wet chamber and the fungus was re-isolated and confirmed based on culture spore morphology.

Statistical analyses

Obtained data on beetle mortality rates were Arc Sin transformed and analyzed in Completely Randomized Design using Web Agri Stat Package 2.0 (WASP) https://ccari.res.in/wasp2.0/.

Results

Isolation and characterization of EPF isolates

During 2017–2018 in Tamil Nadu, Bihar, and Assam fungal-infected insects such as corm weevil, pseudostem weevil, and scarring beetle besides Galleria were collected, reared, and identified. In total, 27 fungal isolates were isolated and purified from the dead beetles and Galleria larvae Table 1. Based on colony color and spore morphology, the isolates were broadly classified as Metarhizium (17 isolates) and Beauveria (10 isolates) as they produced green and white colonies, respectively. Among the fungal isolates, 13 isolates consisting of 8 Beauveria and 5 Metarhizium were obtained from dead adult beetles of B. subcostata, while 8 isolates of Metarhizium and one isolate of Beauveria were isolated from Odoiporus longicollis. Also, one isolate of Beauveria and 4 isolates of Metarhizium were obtained from adult of Cosmopolites sordidus and larvae of Galleria, respectively. Observations on morphological characteristic indicated that Metarhizium isolates produced 4 different colonies and conidial morphologies, while Beauveria showed 2 morphological differences (Fig. 1).

Fig. 1

Colony and conidial morphology of entomopathogenic fungi

Molecular characterization of EPF isolates

Molecular characterization of EPF cultures through sequencing of ITS regions and BLAST analysis with data base sequences revealed that they belonged to B. bassiana (8 isolates), B. brongniartii (2 isolates), M. anisopliae (8 isolates), M. robertsii (6 isolates), M. guizhouense (2 isolates), and M. pinghaense (1 isolate) as they had 100, 94, 99, 99, 100, and100% homology with NCBI data base sequences of MT635020, AB027381, FJ545286, MF681599, HM055445, and HM055446, respectively, and all the isolates details with GenBank accessions were depicted in Table 1.

Bioassay of EPF isolates on Basilepta subcostata

All 27 EPF isolates of Beauveria spp. and Metarhizium spp. along with standard commercial isolates were tested against B. subcostata in vitro (Table 2, Fig. 2). Invariably, all the isolated strains showed significant mortality rates of the beetle in 3 days after treatment and the effects were on par with 4 commercial isolates. In 5 days after treatment, M. anisopliae (NRCBEPF35 and NRCBEPF 36) and B. brongniartii (NRCBEPF27) isolated from B. subcastata from Jorhat, Assam recorded 85–95% mortality rate of the beetle. The effect of the isolate (NRCBEPF27) was significantly better than all commercial isolates and other isolated strains. However, other isolated strains of M. anisopliae (NRCBEPF36), M. pinghaense (NRCBEPF 7), and B. brongniartii (NRCBEPF27) are recorded 100% mortality on the 8th day of treatment (Table 2).

Table 2 In vitro bio-efficacy of Metarhizium and Beauveria isolates against Basilepta subcostata

Fig. 2

Effect of EPF native isolates on Basilepta subcastata after 8 days of inoculation. a Insect cadaver fully covered with bright white mycelia of Beauveria brongniartii. b Insect cadaver fully covered with mycelium of Metarhizium pinghaense. c Insect cadaver covered with conidia of Metarhizium anisopliae

Discussion

Scarring beetle is a major problem in banana cultivation especially in North, East, and North East parts of India; Bangladesh; and South East Asia (Prathapan et al., 2019). It causes severe damage to banana, and it has been estimated up to 95% damage to the crop in different parts of India (Choudhary et al., 2010; Bhagabati and Deka 2016; Saikia et al., 2018 and Daizy et al., 2019). In India, bananas are consumed majorly as raw fruits and some extent as processed food. Therefore, application of chemical pesticides on banana is hugely discouraged. Alternatively, entomo-pathogens have been promising in management of pests in different crops. However, success of the biocontrol agent is mainly depending on efficacy of specific strains against target pest and performance of such agents in the given environment. Hence, the present study focused to collect EPF isolates from North, North East, and Southern parts of India and screen against B. subcostata.

In total, 27 EFP isolates were obtained and based on spore and colony morphologies, and they were characterized (Bischoff et al., 2009; Rehner et al., 2011; Ravindran et al., 2015; and Ramanujam et al., 2015) majorly as Metarhizium (17 isolates) and Beauveria (10 isolates). Molecular identification of fungal species is generally carried out through sequencing of ITS regions (Bischoff et al., 2009; Rehner et al., 2011; Lopes et al., 2013; Kepler et al., 2014; Ravindran et al., 2015; and Ramanujam et al., 2015) and BLAST analysis with data base sequences. Similarly, sequencing of ITS region of EPF cultures revealed that they belonged to B. bassiana, B. brongniartii, M. anisopliae, M. robertsii, M. guizhouense, and M. pinghaense. In the present study, majority of isolates were belonging to Metarhizium spp. followed by Beauveria spp. Over all, comparatively Metarhizium isolates out performed than Beauveria isolates against B. subcastata. Though management strategy for lowering infestation of fruit scaring beetle by bio-pesticide (B. bassiana) was profitable (Samui et al., 2004 and Choudhary et al., 2010), the present study results corroborated with Tuncer et al. (2019) study where Metarhizium isolate showed better results than Beauveria on controlling the coleopteran insect (Ambrosia beetle, Xylosandrus germanus).

Conclusions

EPF isolates M. anisopliae NRCB EPF 35 and NRCB EPF36, and B. brongniartii NRCBEPF27 showed the highest mortality rates of B. subcastata. They could be further exploited to extent a wide spread testing of the isolates against the pest in different ecological zone and to commercialize the strain for wider adoptability by end-users. It also gives the way for preparation of consortium, using the best strains such as NRCBEPF36, NRCBEPF7, and NRCBEPF27. Such M. anisopliae and B. brongniartii strains with biocontrol properties can fit into the Integrated Pest Management (IPM) of the banana fruit scarring beetle, B. subcastata.