Skip to main content
SpringerLink
Log in

Simplified model predictive current control strategy for open-winding permanent magnet synchronous motor drives

  • Original Article
  • Published:
Journal of Power Electronics Aims and scope Submit manuscript

Abstract

For a semi-controlled open-winding permanent magnet synchronous motor, to improve the steady-state control performance of the traditional predictive control system and to concurrently lessen the computation burden, a novel model predictive current control strategy is proposed in this paper. First, to achieve simultaneous control of the d-axis current, q-axis current, and current error-based cost functions. Then, to further reduce the calculation burden and complexity of the prediction algorithm, the predicted voltage of the converter is used as the reference voltage. In addition, the judgment of the sector where the reference voltage is located, and the selection method of the voltage vector are also given. Finally, the effectiveness of the proposed prediction method is tested by the simulation and experimental results.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12

Similar content being viewed by others

References

  1. Cho, D.-H., Bak, Y., Lee, K.-B.: Method of estimating initial rotor position for IPMSMs using subdivided voltage vectors based on inductance variation. J. Power. Electon. 20, 1195–1205 (2020)

    Article  Google Scholar 

  2. Zhang, X., He, Y.: Direct voltage-selection based model predictive direct speed control for PMSM drives without weighting factor. IEEE Trans. Power Electron. 34(8), 7838–7851 (2019)

    Article  Google Scholar 

  3. Lee, Y., Ha, J.: Hybrid modulation of dual inverter for open-end permanent magnet synchronous motor. IEEE Trans. Power Electron. 30(6), 3286–3299 (2015)

    Article  Google Scholar 

  4. An, Q., Liu, J., Peng, Z., Sun, L., Sun, L.: Dual-space vector control of open end winding permanent magnet synchronous motor drive fed by dual inverter. IEEE Trans. Power Electron. 31(12), 8329–8342 (2016)

    Google Scholar 

  5. Sandulescu, A.P., Meinguet, F., Kestelyn, X., Semail, E., Bruyere, A.: Flux-weakening operation of open-end winding drive integrating a cost effective high-power charger. IET Elect. Syst. Transp. 3(1), 10–21 (2013)

    Article  Google Scholar 

  6. Kiadehi, A.D., Drissi, K.E.K., Pasquier, C.: Voltage THD reduction for dual-inverter fed open-end load with isolated DC sources. IEEE Trans. Ind. Electron. 64(3), 2102–2111 (2017)

    Article  Google Scholar 

  7. Chen, M., Sun, D.: A unified space vector pulse width modulation for dual two-level inverter system. IEEE Trans. Power Electron. 32(2), 889–893 (2017)

    Article  Google Scholar 

  8. Edpuganti, A., Rathore, A.K.: New optimal pulse width modulation for single DC-link dual-inverter fed open end stator winding induction motor drive. IEEE Trans. Power Electron. 30(8), 4386–4393 (2015)

    Article  Google Scholar 

  9. Pulvirenti, M., Scarcella, G., Scelba, G.: On-line stator resistance and permanent magnet flux linkage identification on open-end winding PMSM drives. IEEE. Trans. Power. Electron. 55(1), 504–515 (2019). (Jan/Fed. 2019)

    Google Scholar 

  10. Somasekhar, V.T., Gopakumar, K., Shivakumar, E.G., Petit, A.: A multilevel voltage space phasor generation for an open-end winding induction motor drive using a dual inverter scheme with asymmetrical dc link voltages. Eur. Power Electron. Drives J. 12(3), 21–29 (2009)

    Google Scholar 

  11. Moon, J., Kim, C., Park, J., Kang, D., Kim, J.: Circulating current control in MMC under the unbalanced voltage. IEEE. Trans. Power. Del. 28(3), 1952–1959 (2013)

    Article  Google Scholar 

  12. Chong, S., Dan, S., Zheng, Z.: Simplified model predictive control for dual-inverter fed open-winding permanent magnet synchronous motor. IEEE Trans. Energy Convers. 33(4), 1846–1854 (2018)

    Article  Google Scholar 

  13. Sekhar, K.R., Srinivas, S.: Discontinuous decoupled PWMs for reduced current ripple in a dual two-level inverter fed open-end winding induction motor drive. IEEE Trans. Power Electron. 28(5), 2493–2502 (2013)

    Article  Google Scholar 

  14. Mondal, G., Sivakumar, K., Ramchand, R., Gopakumar, K., Levi, E.: A dual seven-level inverter supply for an open-end winding induction motor drive. IEEE. Trans. Ind. Electron. 56(5), 1665–1673 (2009)

    Article  Google Scholar 

  15. Somasekhar, V.T., Gopakumar, K., Baiju, M.R., Mohapatra, K.K., Umanand, L.: A multilevel inverter system for an induction motor with open-end windings. IEEE Trans. Ind. Electron. 52(3), 824–836 (2005)

    Article  Google Scholar 

  16. Mondal, G., Gopakumar, K., Tekwani, P.N., Levi, E.: Are ducked-switch count five-level inverter with common-mode voltage elimination for an open-end winding induction motor drive. IEEE Trans. Ind. Electron. 54(4), 2344–2351 (2007)

    Article  Google Scholar 

  17. Chen, M., Sun, D.: ‘A unified space vector pulse width modulation for dual two-level inverter system. IEEE Trans. Power Electron. 32(2), 889–893 (2017)

    Article  Google Scholar 

  18. Wang, Y., Panda, D., Lipo, T., Pan, D.: Open-winding power conversion systems fed by half-controlled-converters. IEEE Trans. Power Electron. 28(5), 2427–2436 (2013)

    Article  Google Scholar 

  19. Pan, D., and Lipo, T.: Series compensated open-winding PM generator wind generation system. In Proc. 15th Int. Conf. EPE/EPMC LS7c.1–1–LS7c.1–8 (2012)

  20. Zhang, X.G., Li, Y.: Model predictive control of the open-winding PMSG system based on three-dimensional reference voltage-vector. IEEE Trans. Industr. Electron. 67(8), 6312–6322 (2020)

    Article  Google Scholar 

  21. Zhang, X.G., Wang, K.Q.: Current prediction based zero sequence current suppression strategy for the semi-controlled open-winding PMSM generation system with a common DC bus. IEEE Trans. Industr. Electron. 65(8), 6066–6076 (2018)

    Article  Google Scholar 

  22. Zhang, X.G., Zhang, L.: Model predictive current control for PMSM drives with parameter robustness improvement. IEEE Trans. Power Electron. 34(2), 1645–1657 (2018)

    Article  Google Scholar 

  23. Zhang, X.G., Wang, K.Q.: Dual delay-compensation-based model predictive control for the semi-controlled open-winding PMSM system. IEEE ACCESS 7, 69947–69959 (2019)

    Article  Google Scholar 

  24. Sun, X.D., Hu, C.C., Zhu, J.G.: MPTC for PMSMs of EVs with multi-motor driven system considering optimal energy allocation. IEEE Trans. Magn. 55(7), 1–6 (2019)

    Article  Google Scholar 

  25. Wu, M. K., Sun, X. D., Zhu, J. G., Lei G., and Guo, Y. G.: An improved model predictive torque control for PMSM drives based on duty cycle optimization. IEEE Trans. Magn. 57(2), 1–5 (2020)

  26. Sun, X. D., Wu, M. K., Lei, G., Guo Y. G., and Zhu, J. G.: An improved model predictive current control for PMSM drives based on current track circle. IEEE Trans Indust Electron. 68(5), 3782–3793 (2020)

Download references

Acknowledgements

This research was supported by the National Key R&D Program of China (Grant No. 2018YF C1707104) and Shandong Provincial Postgraduate Education Quality Improvement Program of China (Grant No. SDYA119108).

Author information

Authors and Affiliations

  1. College of Electrical and Electronic Engineering, Shan Dong University of Technology, Zibo, China

    Shengjie Zhu & Housheng Zhang

Authors
  1. Shengjie Zhu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Housheng Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Housheng Zhang.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zhu, S., Zhang, H. Simplified model predictive current control strategy for open-winding permanent magnet synchronous motor drives. J. Power Electron. 21, 911–920 (2021). https://doi.org/10.1007/s43236-021-00237-5

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s43236-021-00237-5

Keywords

Search

Navigation