Abstract
In this work, three samples were synthesized; SnO2 nanoparticles, ZnO nanorods and ZnO/SnO2 core–shell nanorods. The preparation of the ZnO/SnO2 composite included two steps, the first was to spin ZnO thin film as a seed layer. The second step is to grow ZnO/SnO2 to produce core–shell nanorod devices. The structure and morphology of the prepared samples were characterized by X-ray diffraction (XRD) and field emission scanning electron microscopy (FE-SEM). Meanwhile, the optical properties were investigated by ultraviolet–visible (UV–Vis) and photoluminescence (PL) spectroscopy. The morphology of the prepared sample revealed that ZnO nanorods were capped by SnO2 shell. The energy band gap of ZnO/SnO2 is lower than that of both bare ZnO and SnO2. Evaluations to near-band (PL) emission of bare ZnO nanorod arrays were considerably reduced by capping with SnO2 sell. The performance of the gas sensor was further examined on the basis of ZnO/SnO2. The response and sensitivity were measured to be 86.6 ( ± 0.5) at optimum operating temperature of 225 °C toward 100 ppm ethanol vapor, which is even higher than those of the bare ZnO nanorods. The local sites added by the SnO2 shell layer could probably stop the excitons from becoming captured by intrinsic defects, leading to improved sensitivity of the gas sensor.
Similar content being viewed by others
References
A.D. Bergstra, B. Brunekreef, A. Burdorf, J. Environ. Health 17, 30 (2018)
Y. Huang, N. Unger, K. Harper, C. Heyes, Atmos. Chem. Phys. 18, 5219 (2018)
A. Kaushik, R. Kumar, R.D. Jayant, M. Nair, J. Pers, Nanomed. 1, 10 (2015)
J. Wang, Analyst 130, 421 (2005)
K.P. Singh, S. Gupta, P. Rai, Atmos. Environ. 80, 426 (2013)
T. Itoh, T. Miwa, A. Tsuruta, T. Akamatsu, N. Izu, W. Shin, J. Park, T. Hida, T. Eda, Y. Setoguchi, Sensors 16, 1891 (2016)
F.K.M. Alosfur, N.J. Ridha, M.H.H. Jumali, S. Radiman, Nanotechnology 29, 145707 (2018)
F.K.M. Alosfur, A.A. Ouda, N.J. Ridha, S.H. Abud, AIP Conf. Proc. 2144, 030025 (2019)
A.A. Ouda, F.K.M. Alosfur, N.J. Ridha, S.H. Abud, N.M. Umran, H.H. Al-aaraji, R.A. Madlool, J. Phys.: Conf. Ser 1032, 012038 (2018)
F.K.M. Alosfur, A.A. Ouda, N.J. Ridha, S.H. Abud, Mater. Res. Exp. 6, 065028 (2019)
H. Mun, H. Yang, J. Park, C. Ju, K. Char, APL Mater. 3, 076107 (2015)
A.A. Yadav, E.U. Masumdar, A.V. Moholkar, M.N. Spallart, K.Y. Rajpure, C.H. Bhosale, J. Alloys Compd. 488, 350 (2009)
A.A. Yadav, Thin Solid Films 591, 18 (2015)
C.F. Liu, C.H. Kuo, T.H. Chen, Y.S. Huang, Coatings 10, 394 (2020)
M.T. Uddin, Y. Nicolas, C.L. Olivier, T. Toupance, L. Servant, M.M. Müller, H.-J. Kleebe, J.R. Ziegler, W. Jaegermann, Inorg. Chem. 51, 7764 (2012)
N.S. McCool, J.R. Swierk, C.T. Nemes, C.A. Schmuttenmaer, T.E. Mallouk, J. Phys. Chem. Lett. 7, 2930 (2016)
S. Pal, S. Maiti, U.N. Maiti, K.K. Chattopadhyay, CrystEngComm. 17, 64 (2015)
M.H.H. Jumali, F.K.M. Alosfur, S. Radiman, N.J. Ridha, M.A. Yarmo, A.A. Umar, Mater Sci Semicond Process. 25, 207 (2014)
F.K.M. Alosfur, M.H. Jumali, S. Radiman, N.J. Ridha, A.A. Umar, Seventh International Conference on Sensing Technology (ICST), IEEE (ICST), 2013 ,777 (2013).
F.K.M. Alosfur, M.H.H. Jumali, S. Radiman, N.J. Ridha, M.A. Yarmo, A.A. Umar, Nanoscale Res. Lett. 8, 346 (2013)
F. Alosfur, M.H. Jumali, S. Radiman, N.J. Ridha, M.A. Yarmo, A.A. Umar, Int. J. Electrochem. Sci. 8, 2977 (2013)
H.B.A. Kadhim, N.J. Ridha, F.K.M. Alosfur, N.M. Umran, R. Madlol, K.J. Tahir, R.T. Ahmed, J. Phys.: Conf. Ser 1032, 012039 (2018)
W. Zhou, Y. Liu, Y. Yang, P. Wu, J. Phys. Chem. C 118, 12 (2014)
B. Sharma, A. Sharma, M. Joshi, J. Myung, Chemosensors 8, 67 (2020)
X. Yang, S. Zhang, Q. Yu, L. Zhao, P. Sun, T. Wang, F. Liu, X. Yan, Y. Gao, X. Liang, S. Zhang, G. Lu, Sens. Actuators B Chem. 281, 415 (2019)
N.J. Ridha, A.A. Umar, F. Alosfur, M.H.H. Jumali, M.M. Salleh, J. Nanosci. Nanotechnol 13, 2667 (2013)
N.J. Ridha, H.B.A. Kadhim, F.K.M. Alosfur, R.T. Ahmed, Mater. Res. Exp. 5, 125008 (2018)
N.J. Ridha, F.K.M. Alosfur, M.H.H. Jumali, S. Radiman, J. Phys. D Appl. Phys. 51, 435101 (2018)
M.H. Haji Jumali, N.J. Ridha, A.A. Umar, M. Yahya, M.M. Salleh, Adv. Mat. Res. 364, 322 (2012)
S. Livraghi, N. Barbero, S. Agnoli, C. Barolo, G. Granozzi, F. Sauvage, E. Giamello, Phys. Chem. Chem. Phys. 18, 22617 (2016)
N.J. Ridha, H.B.A. Kadhim, F.K.M. Alosfur, L.H. Abood, R. Madlol, AIP Conference Proceedings, AIP Publishing LLC, 2144, 030026 (2019).
T. Yang, K. Gu, M. Zhu, Q. Lu, C. Zhai, Q. Zhao, X. Yang, M. Zhang, Sens. Actuators B Chem. 279, 410 (2019)
R.D. Shannon, C.T. Prewitt, Acta. Crystallogr. B. Struct. Sci. 25, 925 (1969)
T. Coman, E.L. Ursu, V. Nica, V. Tiron, M. Olaru, C. Cotofana, M. Dobromir, A. Coroaba, O.-G. Dragos, N. Lupu, O.F. Caltun, C. Ursu, Thin Solid Films 571, 198 (2014)
T. Coman, D. Timpu, V. Nica, C. Vitelaru, A.P. Rambu, G. Stoian, M. Olaru, C. Ursu, Appl. Surf. Sci. 418, 456 (2017)
S. Gu, W. Li, F. Wang, H. Li, H. Zhou, Catal. Sci. Technol. 6, 1870 (2016)
S. Das, V. Jayaraman, Prog. Mater. Sci. 67, 161 (2015)
S. Chakraborty, M. Roy, R. Saha, Water Sci. Technol 81, 508 (2020)
A. Jose, K.S. Devi, D. Pinheiro, S.L. Narayana, J Photochem. Photobiol. B Biol. 187, 25 (2018)
Z.R. Munirah, A. Khan, M.S.K. Aziz, M.U. Khandaker, mater. Sci 35, 246 (2017)
H.F. Haneef, A.M. Zeidell, O.D. Jurchescu, J. Mater. Chem. C. 8, 759 (2020)
M.R. Waikar, P.M. Raste, R.K. Sonker, V. Gupta, M. Tomar, M.D. Shirsat, R.G. Sonkawade, J. Alloys Compd. 830, 154641 (2020)
D.T.T. Le, N.D. Chinh, B.T.T. Binh, H.S. Hong, N. Van Duy, N.D. Hoa, N.V. Hieu, Curr. Appl. Phys. 13, 1637 (2013)
G. Sun, S. Zhang, Y. Li, F. Qi, H. Chen, Z. Zhang, Curr. Nanosci. 11, 405 (2015)
K.W. Kim, P.-S. Cho, S.-J. Kim, J.-H. Lee, C.-Y. Kang, J.-S. Kim, S.-J. Yoon, Sens. Actuators B Chem. 123, 318 (2007)
X. Song, L. Liu, Characterization of electrospun ZnO–SnO2 nanofibers for ethanol sensor. Sens. Actuator A Phys. 154, 175 (2009)
C.C. Li, X.M. Yin, Q.H. Li, T.H. Wang, Cryst. Eng. Comm. 13, 1557 (2011)
W. Li, S. Ma, Y. Li, G. Yang, Y. Mao, J. Luo, D. Gengzang, X. Xu, S. Yan, Sens. Actuators B Chem. 211, 392 (2015)
J. Liu, T. Wang, B. Wang, P. Sun, Q. Yang, X. Liang, H. Song, G. Lu, Sens. Actuators B Chem. 245, 551 (2017)
W. Tang, J Phys D Appl Phys. 50, 475105 (2017)
T. Thanihaichelvan, M. Thanihaichelvan, A. Haseeb, S.A. Akbar, Front. Mater. 6, 122 (2019)
L. Wang, J. Li, Y. Wang, K. Yu, X. Tang, Y. Zhang, S. Wang, C. Wei, Sci. Rep. 6, 35079 (2016)
N.J. Ridha, F.K.M. Alosfur, M.H.H. Jumali, S. Radiman, Nanotechnology 31, 145502 (2020)
M. Wei, C.-F. Li, X.-R. Deng, H. Deng, Energy Procedia 16, 76 (2012)
Y. Mishra, V. Chakravadhanula, V. Hrkac, S. Jebril, D. Agarwal, S. Mohapatra, D. Avasthi, L. Kienle, R. Adelung, J. Appl. Phys. 112, 064308 (2012)
T. Sahm, A. Gurlo, N. Barsan, U. Weimar, Sens. Actuators B Chem. 118, 78 (2006)
J. Rebholz, U. Weimar, N. Barsan, Procedia Eng. 87, 20 (2014)
J. Liu, X. Liu, Z. Zhai, G. Jin, Q. Jiang, Y. Zhao, C. Luo, L. Quan, Sens. Actuators B Chem. 220, 1354 (2015)
M.M. Radhi, F.K.M. Alosfur, N.J. Ridha, Voltammetric characterization of grafted polymer modified with ZnO nanoparticles on glassy carbon electrode. Russ. J. Electrochem. 54, 27 (2018)
N.M. Umran, H.A. Rashed, F.K.M. Alosfur, N.J. Ridha, J. Phys.: Conf. Ser 1032, 012045 (2018)
N.J. Ridha, F.K.M. Alosfur, H.B.A. Kadhimm, L.H. Aboud, N. Al-Dahan, J. Mater. Sci. Mater. Electron. 31, 9835 (2021)
J. Liu, Y. Lu, X. Cui, G. Jin, Z. Zhai, Appl. Phys. A 122, 146 (2016)
N.J. Ridha, F.K.M. Alosfur, M.H.H. Jumali, K.J. Tahir, R.A. Madlol, N. Al-Dahan, AIP Conf. Proc. 2290, 050052 (2020)
N.J. Ridha, M.H.H. Jumali, A.A. Umar, F. Alosfur, Int. J. Electrochem. Sci. 8, 4583 (2013)
Acknowledgement
The authors acknowledge the University of Kerbala for scientific research support. As well, the University of Alkafeel is gratefully acknowledged for financial support.
Author information
Authors and Affiliations
Corresponding authors
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Alosfur, F.K.M., Ridha, N.J. Synthesis and characterization of ZnO/SnO2 nanorods core–shell arrays for high performance gas sensors. Appl. Phys. A 127, 203 (2021). https://doi.org/10.1007/s00339-021-04357-4
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s00339-021-04357-4