Skip to main content
Log in

Effect of carrier fluid and particle size distribution on the rheology of shear thickening suspensions

  • Original Contribution
  • Published:
Rheologica Acta Aims and scope Submit manuscript

Abstract

We present a systematic rheological study on the fumed silica suspensions to understand the effect of particle and fluid parameters on the critical shear rate and shear thickening ratio. It was observed that removal of air bubbles and water contamination is crucial to prepare good shear thickening fluids. A careful sample preparation method was adopted to properly disperse the fumed silica particles in polyethylene glycol solution, and we achieved discontinuous shear thickening at low particle concentration. It was observed that the critical shear rate in shear thickening suspension is strongly influenced by both carrier fluid and particle concentration. However, the shear thickening ratio is mainly influenced by the particle parameters and the frictional forces between the particles. Increasing the amount of smaller particles in the suspension significantly decreases the maximum viscosity and shifts the onset of shear thickening to higher values of critical shear rates with much smaller shear thickening ratio. Further, a possible mechanism has been proposed based on the influence of carrier fluid and particle size distribution to explain the rheological behaviour of shear thickening suspension. Our study supports the theory of particle-particle frictional contacts as the main reason for the discontinuous shear thickening.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10

Similar content being viewed by others

References

  • Barnes HA (1989) Shear-thickening (“dilatancy”) in suspensions of nonaggregating solid particles dispersed in Newtonian liquids. J Rheol 33:329–366

    Article  CAS  Google Scholar 

  • Boersma WH, Laven J, Stein HN (1990) Shear thickening (dilatancy) in concentrated dispersions. AICHE J 36:321–332

    Article  CAS  Google Scholar 

  • Brady JF, Bossis G (1985) The rheology of concentrated suspensions of spheres in simple shear flow by numerical simulations. J Fluid Mech 155:105–129

    Article  Google Scholar 

  • Brown E, Jaeger HM (2009) Dynamic jamming point for shear thickening suspensions. Phy Rev Lett 103(086001):1–4

    Google Scholar 

  • Brown E, Jaeger HM (2012) The role of dilation and confining stresses in shear thickening of dense suspensions. J Rheol 56:875–923

    Article  CAS  Google Scholar 

  • Cheng X, McCoy JH, Israelachvili JN, Cohen I (2011) Imaging the microscopic structure of shear thinning and thickening colloidal suspensions. Science 333:1276–1279

    Article  CAS  Google Scholar 

  • Collins EA, Hoffmann D, Soni PL (1979) Rheology of PVC dispersions: i. Effect of particle size and particle size distribution. J Colloid Interface Sci 71:21–29

    Article  CAS  Google Scholar 

  • Comtet J, Chatt’e G, Nigu’es A, Bocquet L, Siria A, Colin A (2017) Pairwise frictional profile between particles determines discontinuous shear thickening transition in non-colloidal suspensions. Nat Commun 8(15633):1–7

    Google Scholar 

  • D’Haene P, Mewis J (1994) Rheological characterization of bimodal colloidal dispersions. Rheol Acta 33:165–174

    Article  Google Scholar 

  • Dhar S, Chattopadhyay S, Majumdar S (2020) Signature of jamming under steady shear in dense particulate suspensions. J Phys Condens Matter 32(124002):1–6

    Google Scholar 

  • Fall A, Bertand F, Hautemayou D, Meziere C, Moucheront P, Lemaitre A, Ovarlez G (2015) Macroscopic discontinuous shear thickening versus local shear jamming in cornstarch. Phy Rev Lett 114(098301):1–5

    Google Scholar 

  • Fischer C, Braun SA, Bourban PE, Michaud V, Plummer CJG, Manson JAE (2006) Dynamic properties of sandwich structures with integrated shear-thickening fluids. Smart Mater Struct 15:1467–1475

    Article  Google Scholar 

  • Gates Jr LE (1968) Evaluation and development of fluid armor systems. Report no: AFML-TR-68-362

  • Greenwood R, Luckham PF, Gregory T (1997) The effect of diameter ratio and volume ratio on the viscosity of bimodal suspensions of polymer lattices. J Colloid Interface Sci 191:11–21

    Article  CAS  Google Scholar 

  • Gurgen S, Kushan MC (2016) Rheological properties of shear thickening fluids. J Polytech 19:409–414

    Google Scholar 

  • Hoffman RL (1972) Discontinuous and dilatant viscosity behavior in concentrated suspensions. I. Observation of a flow instability. J Rheol 16:155–173

    CAS  Google Scholar 

  • Kalman D, Schein J, Houghton J, Laufer CH, Wetzel ED, Wagner NJ (2007) Polymer dispersion based shear thickening fluid-fabrics for protective applications. Proc SAMPE Baltimore USA 1:35–38

    Google Scholar 

  • Lee YS, Wagner NJ (2003) Dynamic properties of shear thickening colloidal suspensions. Rheol Acta 42:199–208

    Article  CAS  Google Scholar 

  • Lee YS, Wagner NJ (2006) Rheological properties and small-angle neutron scattering of a shear thickening, nanoparticle dispersion at high shear rates. Ind Eng Chem Res 45:7015–7024

    Article  CAS  Google Scholar 

  • Lee BW, Kim IJ, Kim CG (2009) The influence of the particle size of silica on the ballistic performance of fabrics impregnated with silica colloidal suspension. J Compos Mater 43:2679–2698

    Article  CAS  Google Scholar 

  • Maranzano BJ, Wagner NJ (2001) The effects of particle size on reversible shear thickening of concentrated colloidal dispersions. J Chem Phys 114:10514–10527

    Article  CAS  Google Scholar 

  • Maranzano BJ, Wagner NJ (2002) Flow-small angle neutron scattering measurements of colloidal dispersion microstructure evolution through the shear thickening transition. J Chem Phys 117:10291–10302

    Article  CAS  Google Scholar 

  • Mari R, Seto R, Morris JF, Denn MM (2014) Shear thickening, frictionless and frictional rheologies in non-Brownian suspensions. J Rheol 58:1693–1724

    Article  CAS  Google Scholar 

  • Moriana AD, Tian T, Sencadas V, Li W (2016) Comparison of rheological behaviors with fumed silica-based shear thickening fluids. Korea-Australia Rheol J 28:197–205

    Article  Google Scholar 

  • Qin X, Majumdar S, Brown E, Jaeger HM (2014) Shear thickening of highly viscous granular suspension. Eur Phy Lett 107(68004):1–6

    Google Scholar 

  • Qin J, Zhang G, Shi X (2017) Study of a shear thickening fluid: the suspensions of monodisperse polystyrene microspheres in polyethylene glycol. J Dispers Sci Technol 38:935–942

    Article  CAS  Google Scholar 

  • Raghavan SR, Khan SA (1997) Shear-thickening response of fumed silica suspensions under steady and oscillatory shear. J Coll Int Sci 185:57–67

    Article  CAS  Google Scholar 

  • Raghavan SR, Walls HJ, Khan SA (2000) Rheology of silica dispersions in organic liquids: new evidence for solvation forces dictated by hydrogen bonding. Langmuir 16:7920–7930

    Article  CAS  Google Scholar 

  • Royer JR, Blair DL, Hudson SD (2016) Rheological signature of frictional interactions in shear thickening suspensions. Phy Rev Lett 116(188301):1–5

    Google Scholar 

  • Seto R, Mari R, Morris JF, Denn MM (2013) Discontinuous shear thickening of frictional hard-sphere suspensions. Phy Rev Lett 111(218301):1–5

    Google Scholar 

  • Wagner NJ, Brady JF (2009) Shear thickening in colloidal dispersions. Phys Today 62:27–32

    Article  CAS  Google Scholar 

  • Wagner N, Wetzel E (2006) Advanced body armor utilizing shear thickening fluids. US Patent 20060234577A1

  • Warren J, Offenberger S, Toghiani H, Pittman CU, Lacy TE, Kundu S (2015) Effect of temperature on the shear-thickening behavior of fumed silica suspensions. ACS Appl Mater Interfaces 7:18650–18661

    Article  CAS  Google Scholar 

  • Zhang X, Li W, Gong X (2010) Thixotropy of MR shear-thickening fluids. Smart Mater Struct 19(125012):1–6

    Google Scholar 

Download references

Acknowledgments

The authors would also like to thank Nilay Kumar Shahi and Sachin Shrestha for their assistance in conducting the experiments.

Funding

The authors would like to thank the Defence Research and Development Organization, Government of India (Project no. ARMREB/CDSW/2016/175) for their financial support of the research work.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Anugrah Singh.

Additional information

Publisher’s note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Prabhu, T.A., Singh, A. Effect of carrier fluid and particle size distribution on the rheology of shear thickening suspensions. Rheol Acta 60, 107–118 (2021). https://doi.org/10.1007/s00397-021-01257-5

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00397-021-01257-5

Keywords

Navigation