Skip to main content

Advertisement

SpringerLink
Log in

Euphorbia tirucalli stem bark and phylloclades’ oil quality variability and implication for energy use

  • Original Article
  • Published:
Biomass Conversion and Biorefinery Aims and scope Submit manuscript

Abstract

Liquid biofuels have emerged as a worldwide alternative fuel with potential to replace fossil fuels. Due to their wide availability as derivatives of organic materials from plants, they have attracted much attention and investment in developing countries including Tanzania, as alternative sources of energy. This study examined effects of oil quality from stem barks and phylloclades of Euphorbia tirucalli trees of different girth sizes (viz., 20 cm, 30 cm, 40 cm, 50 cm, 60 cm, 70 cm, and 80 cm) from semi-arid, coastal, and southern highlands in Dodoma, Dar es Salaam, and Mbeya Southern highland, agro-ecological zones in Tanzania. Using Soxhlet extraction method, oils were extracted from E. tirucalli stem barks with different girth sizes while oils from phylloclades were extracted from matured apical phylloclades collected from shoots of E. tirucalli trees from which the stem bark samples had been collected. Oil yields were determined by measuring the weight of oil (g) by the total weight of sample extracts used (20 g), and the average oil yield on each sample was determined. Oil quality was evaluated as oxidative stability index (OSI), acid values (AVs), and percent free fatty acids (%FFAs). Their results were then compared with the European Union (EU) oil quality standard specifications prescribed in EN 14214 of 6 h, 0.5 mg KOH/g, max and 0.020 maximum wt% limits, respectively. Differences in the quality of E. tirucalli (stem bark and phylloclades) oil were analyzed statistically with paired-sample t test (two-tailed) using the SPSS 15.0 software package. Results showed that the difference in OSIs from stem barks were not significantly higher (3–5 h) than phylloclades (3–4 h) at the p > 0.5 level. Also, the difference in AVs and %FFAs from the stem barks (7.6–7.4 mg KOH and 3.8–3.6%) was not significantly lower than those from the phylloclades (8.4–8.1 mg KOH and 4.3–4.0%) respectively. The quality of oil from stem bark and phylloclades samples at different stem girth sizes semi-arid agro-ecological zone was not significantly higher than from southern highland and coastal agro-ecological zones, respectively. Thus, there were no significant differences in the quality of E. tirucalli oil (stem bark and phylloclades) among stem girth sizes in different agro-ecological zones. The AVs and %FFAs of oils from stem bark and phylloclades were higher than the recommended standards, while the OSIs were below the biofuel standard limit. High AVs and %FFAs reduced oil quality by producing considerably low OSIs values than recommended standards. Finally, the study concluded that E. tirucalli oil requires purification to reduce levels of AV and %FFA contents so that the oil becomes suitable for application as liquid biofuel for energy generations.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Plate 1
Fig. 1

Similar content being viewed by others

References

  1. Bwapwa JK, Anandraj A, Trois C (2017) Possibilities for conversion of microalgae oil into aviation fuel: a review. Renewable and Sustainable Energy Reviews, pp.:1345–1354. https://doi.org/10.1016/j.rser.2017.05.224

  2. Cheng JJ, Timilsina GR (2011) Status and barriers of advanced biofuel technologies: a review. Renewable Energy 36(12):3541–3549. https://doi.org/10.1016/j.renene.2011.04.031

    Article  Google Scholar 

  3. Nagendrappa G (2000) Liquid fuels from plants: can we meet our petroleum needs from plants? Resonance 5(11):47–55. https://doi.org/10.1007/BF02868493

    Article  Google Scholar 

  4. Loke, J., Mesa, L. A. and Franken, Y. J. (2011) Euphorbia tirucalli bioenergy manual: feedstock production, bioenergy conversion, applications, economics version 2. Available at: http://fact-foundation.com/sites/default/files/library/documents/34._euphorbia_tirucalli_bioenergy_manual.pdf (Accessed: 21 July 2020)

  5. R. Yunus, R. Omar, Z. Z. Abidin, and D. R. A. Biak, Oil palm as bioenergy feedstock, in Palm Oil: Production, Processing, Characterization, and Uses, Elsevier Inc., 2012, pp. 653–692

  6. B. R. Hastilestari et al., Euphorbia tirucalli L.-comprehensive characterization of a drought tolerant plant with a potential as biofuel source, PLoS One, vol. 8, no. 5, p. e63501, May 2013, doi: https://doi.org/10.1371/journal.pone.0063501

  7. D. Kumar, N. Bhatia, and B. Singh, Sustainability of oil seed-bearing bioenergy plants in India (Jatropha, Karanja, and castor) for phytoremediation: a meta-analysis study, in Phytoremediation Potential of Bioenergy Plants, Springer Singapore, 2017, pp. 409–430

  8. W. Abdelmoez, A. M. Tayeb, A. Mustafa, and M. Abdelhamid, Green approach for biodiesel production from jojoba oil supported by process modeling and simulation, Int. J. Chem. React. Eng., vol. 14, no. 1, pp. 185–193, 2016, doi: https://doi.org/10.1515/ijcre-2015-0070

  9. Bruyns PV, Mapaya RJ, Hedderson TJ (2006) A new subgeneric classification for Euphorbia (Euphorbiaceae) in Southern Africa based on its psbA-trnH sequence data, TAXON. International Association for Plant Taxonomy 55(2):397–420. https://doi.org/10.2307/25065587

    Article  Google Scholar 

  10. Van Damme, P. L. J. (2001) Euphorbia tirucalli for high biomass production, in Combating Desertification with Plants, pp. 169–187. doi: https://doi.org/10.1007/978-1-4615-1327-8_16

  11. Priya CL, Rao KVB (2011) A review o phytochemical a pharmacological profile of Euphorbia. Pharmacologyonlene 2(March 2015):384–390

    Google Scholar 

  12. H. Y. Nchimbi, Effects of free fatty acids (FFAs) on the quality of Euphorbia tirucalli (L.) oil extracted from different stem diameters in different agro-ecological zones of Tanzania,” 2018. Accessed: Dec. 23, 2020. [Online]. Available: http://ijetrm.com/

  13. Augustino S, Gillah PR (2005) Medicinal plants in urban districts of Tanzania: plants, gender roles and sustainable use. International Forestry Review 7(1):44–58. https://doi.org/10.1505/Ifor.7.1.44.64157

    Article  Google Scholar 

  14. Batanouny, K. H., Stichler, W. and Ziegler, H. (1991) Photosynthetic pathways and ecological distribution of Euphorbia species in Egypt, Oecologia. Springer-Verlag, 87(4), pp. 565–569. doi: https://doi.org/10.1007/BF00320421

  15. Cushman JC, Borland AM (2002) Induction of Crassulacean acid metabolism by water limitation, Plant, Cell and Environment. Plant Cell Environ 25(2):295–310. https://doi.org/10.1046/j.0016-8025.2001.00760.x

    Article  Google Scholar 

  16. Ohyama, Kanji et al. (2009) Cloning and characterization of a squalene synthase gene from a petroleum plant, Euphorbia tirucalli L., Planta. Planta, 229(6), pp. 1243–1252. doi: https://doi.org/10.1007/s00425-009-0906-6

  17. Nielsen, P. E. et al.(1979) Steroids from Euphorbia and other latex-bearing plants, Phytochemistry. Pergamon, 18(1), pp. 103–104. doi: https://doi.org/10.1016/S0031-9422(00)90923-3

  18. Kamolrat, P. (2005) Determination of oil and hydrocarbon from latex plants for liquid fuel, Kamolrat Photi, A PhD Thesis (Published), Submitted in Partial Fulfillment of the Requirements for the Degree of Master of Science (Appropriate Technology for Resources and Environmental Development). Mahidol University. Available at: http://opac.tistr.or.th/Multimedia/Web/0050/wb0050444.pdf (Accessed: 22 July 2020)

  19. Taylor, L. (2005) The healing power of rainforest herbs : a guide to understanding and using herbal medicinals. Square One Publishers. Available at: https://www.amazon.com/Healing-Power-Rainforest-Herbs-Understanding/dp/0757001440 (Accessed: 22 July 2020)

  20. Kalita D (2008) Hydrocarbon plant-new source of energy for future. Renewable and Sustainable Energy Reviews 12:455–471. https://doi.org/10.1016/j.rser.2006.07.008

    Article  Google Scholar 

  21. Simmons, B. A. (2012) Bioenergy from plants and plant residues, in Plant Biotechnology and Agriculture. Elsevier Inc., pp. 495–505. doi: https://doi.org/10.1016/B978-0-12-381466-1.00031-6

  22. Gunstone, F. D., Harwood, J. L. and Harwood, J. L. (2007) The Lipid Handbook with CD-ROM, The Lipid Handbook with CD-ROM. CRC Press. doi: https://doi.org/10.1201/9781420009675

  23. Yamamoto Y, Mizuguchi R, Yamada Y (1981) Chemical constituents of cultured cells of Euphorbia tirucalli and Euphorbia millii. Plant Cell Reports 1(1):29–30. https://doi.org/10.1007/BF00267653

    Article  Google Scholar 

  24. Costa de Camargo, A. C. et al.(2016) Chemical changes and oxidative stability of peanuts as affected by the dry-blanching, JAOCS, Journal of the American Oil Chemists’ Society. Springer Verlag, 93(8), pp. 1101–1109. doi: https://doi.org/10.1007/s11746-016-2838-1

  25. Adam, K., Natarajan, K. A. and Iwasaki, I. (1984) Grinding media wear and its effect on the flotation of sulfide minerals, International Journal of Mineral Processing, 12(1–3), pp. 39–54. doi: https://doi.org/10.1016/0301-7516(84)90021-8

  26. Knothe, G., Dunn, R. O. and Bagby, M. O. (1997) Biodiesel: the use of vegetable oils and their derivatives as alternative diesel fuels, ACS Symposium Series, pp. 172–208. doi: https://doi.org/10.1021/bk-1997-0666.ch010

  27. Huber GW, Iborra S, Corma A (2006) Synthesis of transportation fuels from biomass: Chemistry, catalysts, and engineering. Chem Rev 106(9):4044–4098. https://doi.org/10.1021/cr068360d

  28. ASTM D6751-15c (2010) Standard specification for biodiesel fuel blend stock (B100) for middle distillate fuels, ASTM International, i, pp. 1–11. doi: https://doi.org/10.1520/D6751

  29. N. H. Y, R. Z. K, and K. J. H Y, Effects of differences in stem diameters on oil yields from the wildly growing E. tirucalli trees in different agro-ecological zones in Tanzania, Int. J. Innov. Res. Multidiscip. F., vol. 4, no. 6, 2018

  30. United Republic of Tanzania (URT) (2007) The United Republic of Tanzania. National Adaptation Programme of Action (NAPA), Prospects. VICE PRESIDENT’S OFFICE, 13(1), pp. 95–103. doi: https://doi.org/10.1007/BF02233368

  31. Rutz, D. and Janssen, R. (2006) Overview and recommendations on biofuel standards for transport in the EU (Contribution to WP 3.2 and WP 5.5), WIP Renewable Energies, (May), p. 26. doi: (EIE/05/022/SI2.420009) Overview

  32. F. Hébert, C. Krause, P. Y. Plourde, A. Achim, G. Prégent, and J. Ménétrier, Effect of tree spacing on tree level volume growth, morphology, and wood properties in a 25-year-old Pinus banksiana plantation in the boreal forest of Quebec, Forests, vol. 7, no. 11, p. 276, 2016, doi: https://doi.org/10.3390/f7110276

  33. Uchida H et al (2004) Plant regeneration from internode explants of Euphorbia tirucalli. Plant Biotechnol. 21(5):397–399. https://doi.org/10.5511/plantbiotechnology.21.397

    Article  Google Scholar 

  34. H. Uchida, K. Ohyama, M. Suzuki, H. Yamashita, T. Muranaka, and K. Ohyama, Triterpenoid levels are reduced during Euphorbia tirucalli l. callus formation, Plant Biotechnol., vol. 27, no. 1, pp. 105–109, 2010, doi: https://doi.org/10.5511/plantbiotechnology.27.105

  35. Kalita, D. and Saikia, C. N. (2004) Chemical constituents and energy content of some latex bearing plants, Bioresource Technology. Elsevier Ltd, 92(3), pp. 219–227. doi: https://doi.org/10.1016/j.biortech.2003.10.004

  36. EN 14112 (2016), Fat and oil derivatives. Fatty acid methyl esters (FAME). Determination of oxidation stability (accelerated oxidation test), EUROPEAN STANDARD, p. 24. Available at: https://shop.bsigroup.com/ProductDetail/?pid=000000000030299494. Accessed 18 July 2020

  37. Atadashi IM, Aroua MK, Aziz AA (2010) High quality biodiesel and its diesel engine application: a review, Renewable and Sustainable Energy Reviews. Elsevier 14(7):1999–2008. https://doi.org/10.1016/j.rser.2010.03.020

    Article  Google Scholar 

  38. Meher, L. C. et al.(2006) Technical aspects of biodiesel production by transesterification-a review, Renewable and Sustainable Energy Reviews. Elsevier, 10(3), pp. 248–268. Available at: https://econpapers.repec.org/RePEc:eee:rensus:v:10:y:2006:i:3:p:248-268 (Accessed: 21 July 2020)

  39. Vaïtilingom, G. (1992) Huiles Végétales - Biocombustible Diesel, Influence de la Nature des Huiles et en Particulier de leur Composition en Acide Gras sur la Qualité-Carburant. Available at: http://publications.cirad.fr/une_notice.php?dk=323973 (Accessed: 22 July 2020)

  40. Jiménez Espadafor F, Torres García M, Becerra Villanueva J, Moreno Gutiérrez, J (2009) The viability of pure vegetable oil as an alternative fuel for large ships. Transp Res D Transp Environ 14(7):461–469. doi: https://doi.org/10.1016/j.trd.2009.05.005

  41. Blin, J. et al. (2013) ‘Characteristics of vegetable oils for use as fuel in stationary diesel engines - towards specifications for a standard in West Africa’, Renewable and Sustainable Energy Reviews 580–597. doi: https://doi.org/10.1016/j.rser.2013.02.018

  42. Daho T et al (2012) Study of droplet vaporization of various vegetable oils and blends of domestic fuel oil-cottonseed oil under different ambient temperature conditions. Biomass and Bioenergy 46:653–663. https://doi.org/10.1016/j.biombioe.2012.06.031

    Article  Google Scholar 

  43. Higelin P. (1992) Huiles Végétales-Biocombustibles Diesel : Incidence Des Aspects Thermiques Liés Au Type De Moteur Sur La Combustion. Université d’Orléans. Available at: https://agris.fao.org/agris-search/search.do?recordID=FR2019128001 (Accessed: 20 July 2020)

  44. N. H. Azeman, N. A. Yusof, and A. I. Othman, Detection of free fatty acid in crude palm oil, Asian Journal of Chemistry, vol. 27, no. 5. Chemical Publishing Co., pp. 1569–1573, 2015, doi: https://doi.org/10.14233/ajchem.2015.17810

  45. L.-L.-N. Benoit Constant, N.-N. Godswill, N.-E. Georges Frank, N.-B. Hermine, N. Achille, and B. J. Martin, African Journal of Food Science, a review of main factors affecting palm oil acidity within the smallholder oil palm (Elaeis guineensis Jacq.) sector in Cameroon, vol. 11, no. 9, pp. 296–301, 2017, doi: https://doi.org/10.5897/AJFS2017.1611

  46. U. Ekwenye, Chemical characteristics of palm oil biodeterioration, Biokemistri, vol. 18, no. 2, 2010, doi: https://doi.org/10.4314/biokem.v18i2.56415

  47. Brou, R. K. et al. (2010) Chemical characterisation of oil from germinated nuts of several coconut cultivars (Cocos nucifera L.), European Journal of Scientific Research, 39(4), pp. 514–522. Available at: https://www.researchgate.net/publication/242552002_Chemical_Characterisation_of_Oil_from_Germinated_Nuts_of_Several_Coconut_Cultivars_Cocos_nucifera_L (Accessed: 21 July 2020)

  48. C. N. Ibeto, C. O. B. Okoye, and A. U. Ofoefule, Comparative study of the physicochemical characterization of some oils as potential feedstock for biodiesel production, ISRN Renew. Energy, vol. 2012, pp. 1–5, 2012, doi: https://doi.org/10.5402/2012/621518

  49. Choe E, Min DB (2006) Comprehensive reviews in food science and food safety mechanisms and factors for edible oil oxidation. Comprehensive Reviews in Food Science and Food Safety 5:169–186. https://doi.org/10.1111/j.1541-4337.2006.00009.x

    Article  Google Scholar 

  50. T. Kivevele, A. K. Agarwal, T. Gupta, and M. Mbarawa, Oxidation stability of biodiesel produced from non-edible oils of African origin,” in SAE 2011 World Congress and Exhibition, 2011, doi: https://doi.org/10.4271/2011-01-1202

  51. Grosshagauer, S., Steinschaden, R. and Pignitter, M. (2019) Strategies to increase the oxidative stability of cold pressed oils, LWT. Academic Press, pp. 72–77. doi: https://doi.org/10.1016/j.lwt.2019.02.046

  52. Melo, E. et al. (2019) First study on the oxidative stability and elemental analysis of Babassu (Attalea speciosa) edible oil produced in Brazil using a domestic extraction machine, Molecules. MDPI AG, 24(23). doi: https://doi.org/10.3390/molecules24234235

  53. Zhu, F. et al. (2011) Health risk assessment of eight heavy metals in nine varieties of edible vegetable oils consumed in China, Food and Chemical Toxicology. Food Chem Toxicol, 49(12), pp. 3081–3085. doi: https://doi.org/10.1016/j.fct.2011.09.019

  54. Nkengurutse, J. et al. (2019) Chemical composition and oral toxicity assessment of Anisophyllea boehmii kernel oil: potential source of new edible oil with high tocopherol content, Food Chemistry. Elsevier Ltd, 278, pp. 795–804. doi: https://doi.org/10.1016/j.foodchem.2018.11.112

  55. Yanishlieva NV, Marinova EM (2001) Stabilisation of edible oils with natural antioxidants, European Journal of Lipid Science and Technology. John Wiley & Sons, Ltd 103(11):752–767. https://doi.org/10.1002/1438-9312(200111)103:11<752::AID-EJLT752>3.0.CO;2-0

  56. Lajara, J. R., Diaz, U. and Quidiello, R. D. (1990) Definite influence of location and climatic conditions on the fatty acid composition of sunflower seed oil, Journal of the American Oil Chemists’ Society. Springer-Verlag, 67(10), pp. 618–623. doi: https://doi.org/10.1007/BF02540410

  57. Hou, Y. et al. (2006) Endothelial-monocyte-activating polypeptide II induces migration of endothelial progenitor cells via the chemokine receptor CXCR3, Experimental Hematology. Exp Hematol, 34(8), pp. 1125–1132. doi: https://doi.org/10.1016/j.exphem.2006.05.021

  58. Duke, J. A. (1983) Handbook of Energy Crops (unpublished), Purdue University, Centre for New Crops and Plants Products. Available at: http://www.energy.wsu.edu/EnergyLibrary/AgricultureMatters/CatalogItemDetail.aspx?id=105 (Accessed: 18 July 2020)

Download references

Author information

Authors and Affiliations

  1. Department of Biology, College of Natural and Mathematical Sciences, University of Dodoma, Dodoma, Tanzania

    Hamisi Yunus Nchimbi

Authors
  1. Hamisi Yunus Nchimbi
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Hamisi Yunus Nchimbi.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Nchimbi, H.Y. Euphorbia tirucalli stem bark and phylloclades’ oil quality variability and implication for energy use. Biomass Conv. Bioref. 13, 2055–2066 (2023). https://doi.org/10.1007/s13399-020-01262-3

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13399-020-01262-3

Keywords

Search

Navigation