Abstract
It was experimentally determined for the first time that, for noncatalytic biodiesel synthesis, the dependence of the partial pressure of methanol on the mole fraction of methanol in rapeseed oil shows a pronounced negative deviation from Raoult’s law. Investigation of the change in the partial pressure of methanol in the noncatalytic reaction of the transesterification of rapeseed oil in 8 h of the reaction at 220°C demonstrated that the efficiency of the increase in the molar excess of methanol decreases, and, at a more than 10-fold molar excess, the amount of the reacted methanol remains unchanged.
Similar content being viewed by others
REFERENCES
Kafarov, V.V. and Meshalkin, V.P., Analiz i sintez khimiko-tekhnologicheskikh sistem. Uchebnik dlya vuzov (Analysis and Synthesis of Chemical Technological Systems. A Textbook for High School), Moscow: Khimiya, 1991.
Kusdiana, D. and Saka, S., Fuel, 2001, vol. 80, pp. 693–698.
Ortiz, F.J.G., J. Supercrit. Fluids, 2020, vol. 160, p. 104788. https://doi.org/10.1016/j.supflu.2020.104788
Meshalkin, V.P. and Khodchenko, S.M., Polym. Sci. Ser. D, 2017, vol. 10, no. 4, pp. 347–352. https://doi.org/10.1134/S1995421217040128
Anastas, P. and Warner, J., Green Chemistry: Theory and Practice, New York: Oxford University Press, 1998.
Glišić, S.B. and Skala, D.U., J. Supercrit. Fluids, 2010, vol. 54, no. 1, pp. 71–80. https://doi.org/10.1016/j.supflu.2010.03.005
Kanna, R., Int. J. Res. Appl. Sci. Eng. Technol., 2018, vol. 6, no. 1, pp. 1573–1574. https://doi.org/10.22214/ijraset.2018.1241
Aghel, B., Mohadesi, M., and Sahraei, S., Chem. Eng. Technol., 2018, vol. 41, no. 3, pp. 598–605.
Zhou, H., Lu, H., and Liang, B., J. Chem. Eng. Data, 2006, vol. 51, pp. 1130–1135. https://doi.org/10.1021/je0600294
Diasakou, M., Louloudi, A., and Papayannakos, N., Fuel, 1998, vol. 77, pp. 1297–1302. https://doi.org/10.1016/S0016-2361(98)00025-8
Mujeeb, M.A., Vedamurthy, A.B., and Shivasharana, C.T., Adv. Appl. Sci. Res., 2016, vol. 7, no. 1, pp. 120–133.
Kasim, N.S., Tsai, T.-H., Gunawan, S., et al., Bioresource Technol., 2008, vol. 100, no. 8, pp. 2399–2403. https://doi.org/10.1016/j.biortech.2008.11.041
Shimoyama, Y., Iwai, Y., Jin, B.S., et al., Fluid Phase Equilib., 2007, vol. 257, no. 2, pp. 217–222. https://doi.org/10.1016/j.fluid.2007.01.034
Glišić, S., Montoya, O., Orlović, A., et al., J. Serb. Chem. Soc., 2007, vol. 72, no. 1, pp. 13–27. https://doi.org/10.2298/JSC0701013G
Sapunov, V.N., Kustov, A.V., Zhilin, V.F., et al., Khim. Prom-st Segodnya, 2012, no. 12, pp. 13–20.
Funding
This work was supported by the Russian Foundation for Basic Research (project no. 18–29–24009).
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated by V. Glyanchenko
Rights and permissions
About this article
Cite this article
Meshalkin, V.P., Sapunov, V.N., Kozlovskii, R.A. et al. Experimental and Calculation Investigation of the Efficiency of Nonanalytic Biodiesel Synthesis in Subcritical Methanol. Dokl Chem 493, 105–107 (2020). https://doi.org/10.1134/S0012500820370016
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0012500820370016