Abstract
In the current time, sustainability and development of internal combustion engines is subjected to two kinds of threats which are fossil fuel depletion and environmental pollution. So, considerable efforts in the world have been exerted to develop and introduce alternative gaseous fuels to replace conventional fuel by partial or total replacement. In this study, the effect of adding acetylene to LPG-fuelled SI engine has been examined. This addition was with flow rates of 500, 750 and 1000 g/h for 25 % load and 1000 g/h for 50 % load, respectively. An experimental investigation has been carried out on 4 stroke, 4- cylinder, water-cooled spark ignition (SI) engine at constant speed (1500 rpm). Also, performance and emissions parameters have been tested at different excess air coefficients (λ = 0.8, 1, 1.2 and 1.7). As a result, it has been found optimum conditions which are the addition of 750 g/h acetylene for 25 % load (almost 41 % of the LPG-acetylene mixture at λ = 1.2) and 1000 g/h for 50 % load (almost 36 % of the LPG-acetylene mixture at λ = 1.5). In addition, hydrocarbon (HC) and carbon monoxide (CO) emissions decreased, while NO emissions increased when compared to that of baseline LPG operation.
Similar content being viewed by others
Abbreviations
- CA:
-
Crank angle (degree)
- ATDC:
-
After top dead center (CA)
- BSFC:
-
Brake specific fuel consumption (g/kWh)
- BTDC:
-
Before top dead center (CA)
- BTE:
-
Brake thermal efficiency (%)
- CD:
-
Combustion duration (milisecond)
- CO:
-
Carbon monoxide
- CO2 :
-
Carbon dioxide
- EGR:
-
Exhaust gas recirculation
- HC:
-
Hydrocarbon
- NO:
-
Nitrogen monoxide
- SI:
-
Spark ignition
- SA:
-
Spark advance
- λ :
-
Lambda (Excess Air Ratio)
References
Brusca, S., Lanzafame, R., Marino Cugno Garrano, A. and Messina, M. (2014). On the possibility to run an internal combustion engine on acetylene and alcohol. Energy Procedia 45, 889–898.
Chitragar, P. R., Shivaprasad, K. V., Nayak, V., Bedar, P. and Kumar, G. N. (2016). An experimental study on combustion and emission analysis of four cylinder 4-stroke gasoline engine using pure hydrogen and LPG at idle condition. Energy Procedia 90, 525–534.
Das, L. M. (2002). Hydrogen engine: research and development (R&D) programmes in Indian Institute of Technology (IIT), Delhi. Int. J. Hydrogen Energy 27, 9, 953–965.
Gupta, H. N. (1992). Fundamentals of Internal Combustion Engines. PHI Learning Pvt. Ltd. New Delhi.
Ilhak, M. I., Akansu, S. O., Kahraman, N. and Unalan, S. (2018). Experimental study on an SI engine fuelled by gasoline/acetylene mixtures. Energy 151, 707–714.
Internation Energy Agency (2017). Global energy & CO2 status report the latest trends in energy and emissions in 2007. IEA World Energy Outlook 2017.
Karim, G. A. (1983). The dual-fuel engine of the compression ignition type-prospects, problems and solutions-a review. SAE Trans., 92, 569–577.
Karim, G. A. (1968). Ignition of a premixed fuel and air charge by pilot fuel spray injection with reference to dual-fuel combustion. SAE Trans., 77, 3017–3024.
Karim, G. A., Klat, S. R. and Moore, N. P. W. (1966). The knock in dual-fuel engines. Proc. Institute of Mechanical Engineers 181, 1, 453–466.
Lakshmanan, T. and Nagarajan, G. (2010a). Experimental investigation on dual fuel operation of acetylene in a DI diesel engine. Fuel Processing Technology 91, 5, 496–503.
Lakshmanan, T. and Nagarajan, G. (2010b). Experimental investigation of timed manifold injection of acetylene in direct injection diesel engine in dual fuel mode. Energy 35, 8, 3172–3178.
Lakshmanan, T. and Nagarajan, G. (2011). Experimental investigation of port injection of acetylene in DI diesel engine in dual fuel mode. Fuel 90, 8, 2571–2577.
Lee, K. and Ryu, J. (2005). An experimental study of the flame propagation and combustion characteristics of LPG fuel. Fuel 84, 1116–1127.
Lovell, W. G. (1948). Knocking characteristics of hydrocarbons. Industrial & Engineering Chemistry 40, 12, 2388–2438.
Mendera, K. Z., Spyra, A. and Smereka, M. (2002). Mass fraction burned analysis. J. KONES Internal Combustion Engines, 3–4, 193–201.
Nayak, V., Rashmi, G. S., Chitragar, P. and Mohanan, P. (2016). Combustion characteristics and cyclic variation of a LPG fuelled MPFI four cylinder gasoline engine. Energy Procedia 90, 470–480.
Pulkrabek, W. W. (2003). Engineering Fundamentals of the Internal Combustion Engine. 2nd edn. Prentice Hall. Englewood Cliffs, New Jersey.
Shivaprasad, K. V., Raviteja, S., Chitragar, P. and Kumar, G. N. (2014). Experimental investigation of the effect of hydrogen addition on combustion performance and emissions characteristics of a spark ignition high speed gasoline engine. Procedia Technology 14, 141–148.
Sonthalia, A., Rameshkumar, C., Sharma, U., Punganur, A. and Abbas, S. (2015). Combustion and performance characteristics of a small spark ignition engine fuelled with HCNG. J. Engineering Science and Technology 10, 4, 404–419.
Stone, R. (1992). Introduction to Internal Combustion Engine. 2nd edn. The Macmillan Press Ltd. London.
Acknowledgement
The authors would like to acknowledge Erciyes University for the Scientific Research Projects Unit of Erciyes University, Turkey, for the financial support under the grant number FLY-2017-7745.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Cinar, G., Eldamanhory, A., Akansu, S.O. et al. Experimental Study on an Si Engine Fuelled by LPG/Acetylene Mixtures. Int.J Automot. Technol. 21, 1323–1331 (2020). https://doi.org/10.1007/s12239-020-0125-5
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12239-020-0125-5