Skip to main content
SpringerLink
Log in

Influence of hydrated lime on linear viscoelastic properties of bituminous mastics

  • Published:
Mechanics of Time-Dependent Materials Aims and scope Submit manuscript

Abstract

The influence of hydrated lime (HL) on linear viscoelastic (LVE) behavior of mastic is investigated. One bitumen and five mastics with different HL content are investigated. The same 35/50 penetration grade bitumen was tested and used for mastics preparation. The LVE properties were obtained by means of complex shear modulus tests using a dynamic shear rheometer (DSR) on a wide range of temperatures and frequencies.

The time–temperature superposition principle in the LVE domain was applicable. Experimental results were modeled using the 2S2P1D model previously developed at the University of Lyon/ENTPE. The reinforcement effect of HL on LVE behavior of mastics was observed and quantified. Results show that the volume of filler increase when limestone is replaced by HL at constant mass, may explain a large part of the observed stiffening effect.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12

Similar content being viewed by others

References

  • Anderson, D.A., Goetz, W.H.: Mechanical behavior and reinforcement of mineral filler-asphalt mixtures. J. Assoc. Asph. Paving Technol. 42, 37–66 (1973)

    Google Scholar 

  • Delaporte, B., Di Benedetto, H., Chaverot, P., Gauthier, G.: Linear viscoelastic properties of bituminous materials: from binders to mastics (with discussion). J. Assoc. Asph. Paving Technol. 76, 445–494 (2007)

    Google Scholar 

  • Delaporte, B., Di Benedetto, H., Chaverot, P., Gauthier, G.: Effect of ultrafine particles on linear viscoelastic properties of mastics and asphalt concretes. Transp. Res. Rec. 2051, 41–48 (2008)

    Article  Google Scholar 

  • Delaporte, B., Di Benedetto, H., Chaverot, P., Gauthier, G.: Linear viscoelastic properties of bituminous materials including new products made with ultrafine particles. Road Mater, Pavement Des. 10(1), 7–38 (2009)

    Article  Google Scholar 

  • Di Benedetto, H., Delaporte, B., Sauzeat, C.: Three dimensional linear behavior of bituminous materials: experiments and modeling. Int. J. Geomech. 7, 149–15 (2007)

    Article  Google Scholar 

  • Di Benedetto, H., Olard, F., Sauzéat, C., Delaporte, B.: Linear viscoelastic behavior of bituminous materials: from binders to mixes. Road Mater, Pavement Des. 5(SI), 163–202 (2004)

    Article  Google Scholar 

  • Di Benedetto, H., Sauzéat, C., Clec’h, P.: Anisotropy of bituminous mixture in the linear viscoelastic domain. Mech. Time-Depend. Mater. 20(3), 281–297 (2016)

    Article  Google Scholar 

  • Durand, A., Morel, J., Sutton, O., Muller, G.: Investigations on bitumen/polymer/filler interactions and rheological properties of mastics. In: Proc., RILEM 1997, Mechanical Tests for Bituminous Materials, pp. 173–178 (1997)

    Google Scholar 

  • Gayte, P., Di Benedetto, H., Sauzéat, C., Nguyen, Q.T.: Influence of transient effects for analysis of complex modulus tests on bituminous mixtures. Road Mater, Pavement Des. 17(2), 271–289 (2016)

    Article  Google Scholar 

  • Jiang, J., Ni, F., Yao, L., Cui, X.: Evaluating the mastic distribution of asphalt mixtures based on a new thickness threshold using 2D image planers. Road Mater. Pavement Des. 19, 1422–1435 (2018). https://doi.org/10.1080/14680629.2017.1323001

    Article  Google Scholar 

  • Johansson, L.S., Isacsson, U.: Effect of filler on low temperature physical hardening of bitumen. Constr. Build. Mater. 12, 463–470 (1998)

    Article  Google Scholar 

  • Kim, Y.R., Little, D.N.: Linear viscoelastic analysis of asphalt mastics. J. Mater. Civ. Eng. 16(2) (2004). https://doi.org/10.1061/(ASCE)0899-1561(2004)16:2(122)

  • Kim, Y.R., Little, D.N., Song, I.: Effect of mineral fillers on fatigue resistance and fundamental characteristics. Transp. Res. Rec. 183, 1–8 (2003)

    Article  Google Scholar 

  • Kuity, A., Das, A.: Effect of filler gradation on creep response of asphalt mix. Road Mater, Pavement Des. 18(4), 913–928 (2016)

    Article  Google Scholar 

  • Lackner, R., Spiegl, M., Blab, R., Eberhardsteiner, J.: Is low-temperature creep of asphalt mastic independent of filler shape and mineralogy? Arguments from multiscale analysis. J. Mater. Civ. Eng. 17(5), 485–491 (2005). https://doi.org/10.1061/(ASCE)0899-1561(2005)17:5(485)

    Article  Google Scholar 

  • Lesueur, D., Little, D.N.: Effect of hydrated lime on rheology, fracture, and aging of bitumen. Transp. Res. Rec. 1681, 93–105 (1999)

    Article  Google Scholar 

  • Lesueur, D., Petit, J., Ritter, H.J.: The mechanisms of hydrated lime modification of asphalt mixtures: a state-of-the-art review. Road Mater, Pavement Des. 14(1), 1–16 (2013)

    Article  Google Scholar 

  • Lesueur, D., Blazquez, M.L., Garcia, D.A., Rubio, A.R.: On the impact of the filler on the complex modulus of asphalt mixtures. Road Mater. Pavement Des. 19, 1057–1071 (2018). https://doi.org/10.1080/14680629.2017.1288653

    Article  Google Scholar 

  • Liao, M.C., Chen, J.S.: Zero shear viscosity of bitumen-filler mastics. J. Mater. Civ. Eng. 23(12) (2011). https://doi.org/10.1061/(ASCE)MT.19435533.000033

  • Mangiafico, S., Di Benedetto, H., Sauzéat, C., Olard, F., Pouget, S., Planque, L.: Influence of reclaimed asphalt pavement content on complex modulus of asphalt binder blends and corresponding mixes: experimental results and modelling. Road Mater, Pavement Des. 14(1), 132–148 (2013)

    Article  Google Scholar 

  • Mangiafico, S., Di Benedetto, H., Sauzéat, C., Olard, F., Pouget, S., Planque, L.: New method to obtain viscoelastic properties of bitumen blends from pure and reclaimed asphalt pavement binder constituents. Road Mater, Pavement Des. 15(2), 312–329 (2014)

    Article  Google Scholar 

  • Mannan, U.A., Islam, M., Weldegiorgis, M., Tarefder, R.: Experimental investigation on rheological properties of recycled asphalt pavement mastics. Appl. Rheol. 25, 22753 (2015)

    Google Scholar 

  • Olard, F., Di Benedetto, H.: General ‘2S2P1D’ model and relation between the linear viscoelastic behaviors of bituminous binders and mixes. Road Mater, Pavement Des. 4(2), 185–224 (2003)

    Google Scholar 

  • Palade, L.I., Attané, P., Camaro, S.: Linear viscoelastic behavior of asphalt and asphalt based mastic. Rheol. Acta 39(2), 180–190 (2000)

    Article  Google Scholar 

  • Perraton, D., Di Benedetto, H., Sauzéat, C., Hofko, B., Graziani, A., Nguyen, Q.T., Pouget, S., Poulikakos, L.D., Tapsoba, N., Grenfell, J.: 3Dim experimental investigation of linear viscoelastic properties of bituminous mixtures. Mater. Struct. 49(11), 4813–4829 (2016)

    Article  Google Scholar 

  • Pham, N.H., Sauzéat, C., Di Benedetto, H., Gonzalez-Leon, J.A., Barreto, G., Nicolaï, A., Jakubowski, M.: Analysis and modeling of 3D complex modulus tests on hot and warm bituminous mixtures. Mech. Time-Depend. Mater. 19(2), 167–186 (2015)

    Article  Google Scholar 

  • Phan, C.V., Di Benedetto, H., Sauzéat, C., Lesueur, D.: Influence of hydrated lime on linear viscoelastic properties of mastics. In: Proc., 6th Eurasphalt & Eurobitume Congress, Paper 211. Eurobitum and European Asphalt Pavement Association (EAPA), Prague (2016)

    Google Scholar 

  • Phan, C.V., Di Benedetto, H., Sauzéat, C., Lesueur, D., Pouget, S., Olard, F., Dupriet, S.: Complex modulus and fatigue resistance of bituminous mixtures containing hydrated lime. Constr. Build. Mater. 139, 24–33 (2017)

    Article  Google Scholar 

  • Pouget, S., Sauzéat, C., Di Benedetto, H., Olard, F.: From the behavior of constituent materials to the calculation and design of orthotropic bridge structures. Road Mater, Pavement Des. 11(SI), 111–144 (2010)

    Article  Google Scholar 

  • Pouget, S., Sauzéat, C., Di Benedetto, H., Olard, F.: Modeling of viscous bituminous wearing course materials on orthotropic steel deck. Mater. Struct. 45(7), 1115–1125 (2012)

    Article  Google Scholar 

  • Riccardi, C., Cannone Falchetto, A., Losa, M., Wistuba, M.P.: Development of simple relationship between asphalt binder and mastic based on rheological tests. Road Mater. Pavement Des. 19, 18–35 (2018). https://doi.org/10.1080/14680629.2016.1230514

    Article  Google Scholar 

  • Rieksts, K., Pettinari, M., Haritonovs, V.: The influence of filler type and gradation on the rheological performance of mastics. Road Mater, Pavement Des. (2018). https://doi.org/10.1080/14680629.2018.1428216

    Article  Google Scholar 

  • Roberto, A., Romeo, E., Montepara, A., Roncella, R.: Effect of fillers and their fractional voids on fundamental fracture properties of asphalt mixtures and mastics. Road Mater, Pavement Des. (2018). https://doi.org/10.1080/14680629.2018.1475297

    Article  Google Scholar 

  • Santagata, E., Baglieri, O., Tsantilis, L., Dalmazzo, D., Chiappinelli, G.: Fatigue and healing properties of bituminous mastics reinforced with nano-sized additives. Mech. Time-Depend. Mater. 20(3), 367–387 (2016)

    Article  Google Scholar 

  • Shashidhar, N., Romero, P.: Factors affecting the stiffening potential of mineral fillers. Transp. Res. Rec. 1638, 94–100 (1998)

    Article  Google Scholar 

  • Tapsoba, N., Sauzéat, C., Di Benedetto, H., Baaj, H., Ech, M.: Behaviour of asphalt mixtures containing reclaimed asphalt pavement and asphalt shingle. Road Mater, Pavement Des. 15(2), 330–347 (2014)

    Article  Google Scholar 

  • Tunnicliff, D.G.: Binding effect of mineral filler. Proc. Assoc. Asph. Paving Technol. 36, 114–154 (1967)

    Google Scholar 

  • Van Rompu, J., Di Benedetto, H., Buannic, M., Ruot, C.: New fatigue test on bituminous binders: experimental results and modeling. Constr. Build. Mater. 37, 197–208 (2012)

    Article  Google Scholar 

  • Wang, D., Wang, L., Gu, X., Zhou, G.: Effect of basalt fiber on the asphalt binder and mastic at low temperature. J. Mater. Civ. Eng. 25(3) (2013). https://doi.org/10.1061/(ASCE)MT.1943-5533.0000605

    Article  Google Scholar 

  • Williams, M.L., Landel, R.F., Ferry, J.D.: The temperature dependence of relaxation mechanisms in amorphous polymers and other glass-forming liquids. J. Am. Chem. Soc. 77, 3701–3707 (1955)

    Article  Google Scholar 

  • Wortelboer, J.P., Hoppen, H.J., Ramond, G., Pastor, M.: Rheological properties of bitumen/filler mixtures. In: Proc., 1st Eurasphalt & Eurobitume Congress, Paper 4.079. Eurobitum and European Asphalt Pavement Association (EAPA), Brussels (1996)

    Google Scholar 

  • Yusoff, N.I.Md., Mounier, D., Marc-Stephane, G., Hainin, M.R., Airey, G.D., Di Benedetto, H.: Modelling the rheological properties of bituminous binders using the 2S2P1D model. Constr. Build. Mater. 38, 395–406 (2013)

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Univ. Lyon, ENTPE, LTDS (CNRS UMR 5513), 69120, Vaulx-en-Velin, France

    Cong Viet Phan, Hervé Di Benedetto & Cédric Sauzéat

  2. LHOIST Southern Europe, 38030 Grenoble France, 38360, Sassenage, France

    Didier Lesueur

  3. EIFFAGE Infrastructures, Research & Innovation Department, 69964, Corbas, France

    Simon Pouget

Authors
  1. Cong Viet Phan
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Hervé Di Benedetto
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Cédric Sauzéat
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Didier Lesueur
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Simon Pouget
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Hervé Di Benedetto.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Phan, C.V., Di Benedetto, H., Sauzéat, C. et al. Influence of hydrated lime on linear viscoelastic properties of bituminous mastics. Mech Time-Depend Mater 24, 25–40 (2020). https://doi.org/10.1007/s11043-018-09404-x

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11043-018-09404-x

Keywords

Search

Navigation